Garneau's Garage, Inc.
SNOWMOBILE PRE SEASON Check List
|
SERVICE TYPE AND COST. |
SERVICE PROVIDED |
|
Type I |
Check for any service/warranty bulletins. (Ski-Doo only) |
|
Labor for check $55 SDI / $80 twin / $105 triple. |
General Inspection. |
|
Plus parts, grease and fluids. |
Grease chassis / lube steering mechanism |
|
|
Remove rags from exhaust |
|
|
Clean plugs (replace if necessary) |
|
|
Remove & clean carbs (adjust if necessary) |
|
|
Check fuel lines & connections |
| Check lights, tether, kill, ignition switches. | |
|
|
|
|
Type II (includes Type I service plus:) |
Check suspension condition & torque strap |
|
Labor for check $80 SDI / $110 twin / $135 triple |
Check idler wheels, bearings, sliders |
|
Plus parts, grease and fluids |
Check ski's and runners condition |
|
|
Check steering components & front suspension |
|
|
Check & charge battery (if applicable) |
|
|
Check starter rope condition |
|
|
Check condition of throttle cable |
|
|
Check braking system (adjust if needed) |
|
|
Check and adjust drive chain tension |
|
|
Check fan belt condition or coolant level and condition |
|
|
Check injection oil pump and lines and adjust |
|
|
Check clutch bolt |
|
|
Check clutch alignment |
|
|
Check torque bumper |
|
|
Check driven pulley pre load |
|
|
Check track tension & alignment |
| Check ski toe-in | |
| Change chain case oil | |
| Wash | |
|
|
|
|
Type III (includes Type I and II service plus:) |
Compression and Air Leak Test |
|
Labor for check $260 twin / $300 triple |
Injection oil filter replacement |
|
|
In Line Fuel filter replacement |
|
|
Remove and Clean Drive Clutch |
|
|
Remove and Clean Driven Clutch |
|
|
Perform Ski Alignment |
|
|
Wash Under hood |
|
|
Wax |
All prices are labor only for checks performed, if a problem is noted the customer will be notified and additional parts and labor will be extra. Oil injection container and fuel tanks are not filled unless instructed to do so by customer. All work is performed by Ski-Doo Certified technicians.
Auto Care Information
|
Description |
Rate |
|
Labor, for vehicle, snowmobile - ATV's, and trailer repairs. |
$50 / hour |
|
Welding / Fabricating |
$50 / hour |
|
State Inspection, Pass or Fail |
$35 |
|
Oil, Filter, Grease job change and check over. |
$24.00 and up |
|
Wheel Alignment |
$60 and up |
|
Mount or dismount tire to wheel |
$6 each |
|
Spin Balance tire and wheel |
$6 each |
|
Tire Disposal |
$5 each |
Snowmobile summer storage procedure.
Fee for service excluding additional work needed: $40 or Less
|
Quick visual check over for any obvious problems. |
|
Add fuel stabilizer (4oz per Gallon) |
|
Remove Belt |
|
Apply penetrating fluid to ALL corrodible surfaces. |
|
Lube tie rod ends with lithium grease. |
|
Grease all Zerk fittings. |
|
Disconnect negative battery terminal (either end). |
|
Put rags in exhaust & air box openings. |
|
Wash, apply cover and store with track off ground. |
